Marquez Gonzalez, Mayra (2009-05). Heat resistance and outgrowth of clostridium perfringens spores as affected by the type of heating medium, and heating and cooling rates in ground pork. Doctoral Dissertation.
Thesis
The survival and germination of Clostridium perfringens spores in different heating media and at different heating rates was studied to determine the fate of C. perfringens spores during abusive cooking and cooling of pork products. The heat resistance (HR) of C. perfringens spores from three strains that were either previously heat shocked (HS) or non-heat shocked (NHS) was determined individually and as a cocktail in phosphate buffer solution (pH 7.4) (PBS), beef gravy (BG), ground pork (GP) and cured ground pork (CGP) at 75oC. The effect of the heating rate on HR, germination and outgrowth of C. perfringens spores in CGP was determined by increasing the temperature from 20 to 75oC at a rate of 4, 8, and 12oC/h prior to heating and holding at 75oC for 48 h. Heating rates at 4oC/h in GP and CGP were repeated with additional cooling from 54.4 to 7.2oC within 20 h (temperature abuse). Linear survival curves were observed on NHS spores in the four heating media, whereas HS spores showed linear curves when heated in PBS and BG, and biphasic curves when heated in GP and CGP. In general, HS spores were more heat sensitive than NHS spores. NHS spores heated in GP had greater HR than spores heated in CGP, BG or PBS. There were no significant differences (P>0.05) on the HR of C. perfringens spores in CGP heated from 20 to 75oC at 4, 8, or 12oC/h. Heating rates of 8 and 12oC/h showed no difference in germination and outgrowth of inoculated spores, whereas at 4oC/h, growth of C. perfringens occurred between 44 and 56oC. Temperature abuse during cooling of GP resulted in 2.8 log CFU/g increase of C. perfringens counts. In CGP, C. perfringens counts decreased by 1.1 log CFU/g during cooling from 54.4 to 36.3oC and then increased by 1 log CFU/g until the product reached 7.2oC. However, with an initial inoculum in raw CGP of 5 log CFU C. perfringens spores/g, C. perfringens counts did not exceed 3.4 log CFU/g during a 20 h abusive cooling. These results suggest there is no risk associated with C. perfringens in cured pork products under the conditions tested. Results from the present study indicate that different behavior may be expected with different meat products.
